Page Links.& Contents Index

Below are Contents of my WEB site and to Links inside this site.
Consider this page as a book index before opening the pages.

Email Brian, Click Here


Note the American date style.

Fight Spam! Click Here!

Home Page:- 
 Back to the entrance Home Page for links to Peugeot and Motorhome pages.

About Me:- 
Here's some personal "Stuff" about me

www.arcsystems.biz
The Carver Expert

This section will take you to the Peugeot Boxer pages. See below, which has information regarding the Base/Van part of the vehicle.

1-1. Dash Panel lamps. How to replace them..................

To Peugeot Page 1

1-2. Fuse Panel of the Peugeot Boxer..............................

To Peugeot Page 1

1-3. Rust Prevention on front cross beam, Removing the front Bumper, and how the work was done...Plus removal/replacement of the cross member...Views of a rust damaged cross member.......

To Peugeot Page 1

2-1. Radiator Modification - Adding a Control Switch for radiator fans To control overheating of Radiator...

To Peugeot Page 2

2-2. Removing .The Loudspeaker Panel to enable the Control Switch modification.

To Peugeot Page 2

2-3. Email from: MMM - INTERCHANGE.Ref. Overheating .........

To Peugeot Page 2

2-4. Email Messages...Ref. overheating..............................

To Peugeot Page 2

2-5. Radiator Over Heating ...................................................

To Peugeot Page 2

2-6. Antifreeze Change..........................................................

To Peugeot Page 2

2-8. Changing the Heater Matrix........................................

To Peugeot Page 2

2-9. Changing the Cooling Thermostat..................................

To Peugeot Page 2

3-1. Security Project .Roll Bolts Door Locks - installation.............

To Peugeot Page 3

4-1. Spare Wheel & tyre pressure monitoring and fitting of parts.

To Peugeot Page 4

5-1. Tyre Pressures. Conflicting information plate on the door pillar.

To Peugeot Page 5

5-2. Faulty tyres while on holiday................................................

To Peugeot Page 5

6-1.  Engine, Checking Glow Plugs & Replacing with new plugs.......

To Peugeot Page 6

6-2. High Level Rear Stop light...............................................................

To Peugeot Page 6

6-3. Rear Light Assembly Faults ............................................................

To Peugeot Page 6

6-4. A Double horn Modification............................................................

To Peugeot Page 6

6-5. Horn Location...........................................................

To Peugeot Page 6

7-1.  Switch operated Electric Windows Winder, Modification & Installation.....

To Peugeot Page 7

7-2. Schematic Drawing of electric windows.........................

To Peugeot Page 7

7-3. Door Switches  for electric windows................................

To Peugeot Page 7

7-4. Removing dash panels while modifying the electric windows ..

To Peugeot Page 7

7-5. Access to Fuse Box while modifying the electric windows.....

To Peugeot Page 7

7-6. Rigid Sleeve Plugs/Tubes for door panels and electric windows.

To Peugeot Page 7

7-7. Installation Instructions for electric windows modification..

To Peugeot Page 7

8-1. Links to web sites for spares & Help ....................................

To Peugeot Page 8

8-2. Engine Service and Checking Levels [Part 1] ......................

To Peugeot Page 8

8-3. IMPORTANT Safety Recall for the Boxer........................

To Peugeot Page 8

8-4. Images of engine components...........................................

To Peugeot Page 8

8-5. Checking the gear box Oil Level and re-filling..................

To Peugeot Page 8

9-1.  Engine Service & Checking oil Levels [Part 2] ...................

To Peugeot Page 9

9-2. Diesel fuel filter ........................................................................

To Peugeot Page 9

9-3. Starting the engine advice ............................................

To Peugeot Page 9

10-1. Reverse Camera Installation and modification to monitor...

To Peugeot Page 10

11-1. The Load Compensating Valve................................................

To Peugeot Page 11

11-2. Modifications to Rear Springs using Spring Assisters  .....

To Peugeot Page 11

12-1. 6000Mile Service...........................................................................

To Peugeot Page 12

12-2. Automatic Tyre Pressure Monitor...........................................

To Peugeot Page 12

13-1. Hydraulic Head lamp Adjusters.................................................

To Peugeot Page 13

14-1. Battery Maintenance,  checking battery..................................

To Peugeot Page 14

14-2. Alternator and charging...........................................................

To Peugeot Page 14

14-3. Solar Panel Charger .......................................................

To Peugeot Page 14

14-4.  Removing terminals from the battery during a layup...........

To Peugeot Page 14

14-5.  New Plastic Tray and acid damage............................................

To Peugeot Page 14

15-1.  Peugeot Turbo Charger Description ........................................

To Peugeot Page 15

15-2. Peugeot Turbo Illustrations......................................................

To Peugeot Page 15

16-1.  Vehicle maintenance - The Peter Russek Manual................

To Peugeot Page 16

17-1.  The Boxer Diesel Annual MoT...................................................

To Peugeot Page 17

18-1. Connecting pipes in the engine bay............................................

To Peugeot Page 18

18-2. Diesel Fuel to Pump illustrated  ................................................

To Peugeot Page 18

18-3. Brake Vacuum Pump on engine block.......................................

To Peugeot Page 18

19-1. Removal and replacing the Radiator .......................................

To Peugeot Page 19

19-2. Pictures of the radiator removal/..........................................

To Peugeot Page 19

20-1. Simple Fuse Tester....................................................................

To Peugeot Page 20

21-1.  Fitting a New Turbo Charger Boost Gauge..........................

To Peugeot Page 21

22-1. Rust Treatment & Prevention...................................................

To Peugeot Page 22

8-1. Engine Relay control of the 12 volt electrics to the caravan section..............

To Wanderer Page 8

This section below, will take you to the Motorhome pages, which have information about the Caravan area of the vehicle.

The Autohomes Wanderer.
1-1. Our Motorhome description .......................................................

 
To Wanderer Page 1

1-2. With Seat belts..............................................................................

To Wanderer Page 1

1-3. Modifications & additions since purchased...........................

To Wanderer Page 1

2-1. Links to other sites which include locations for spare parts.

To Wanderer Page 2

2-2. Arriving on Camp Site.................................................................

To Wanderer Page 2

2-3. Departing  Camp Site.................................................................

To Wanderer Page 2

2-4. Caravan  Club Hook-up Connection Advice...........................

To Wanderer Page 2

2-5. Security for the Motorhome...................................................

To Wanderer Page 2

2-6. Graphics  Makeover. Information for Graphics to Motorhomes.

To Wanderer Page 2

3-1. 'PLASPLUGS Damp Tester-Damp Checks & 'rapitest' DampTester..........

To Wanderer Page 3

4-1. First impressions of our new purchase..................................

To Wanderer Page 4

4-2. C.A.K. Waste Tap & Replacement Also a recent new chrome tap replacement for grey water waste tank.................

To Wanderer Page 4

5-1.  Urgent Repairs to the back wall of the Motorhome.

To Wanderer Page 5

6-1. Motorhome  Fridge Introduction.............................................

To Wanderer Page 6

6-2. Changing the gas burner in the fridge...................................

To Wanderer Page 6

6-3. Fridge Controls ............................................................................

To Wanderer Page 6

6-4. Operating Instructions................................................................

To Wanderer Page 6

6-5. Adding a Thermal Circulating Fan For the Fridge................

To Wanderer Page 6

6-6.Removal of the 230 Volt Fridge Element................................

To Wanderer Page 6

6-7.Oct 04 Fridge Draughts Solution...............................................

To Wanderer Page 6

6-8. Dometic Q & A faults...................................................................

To Wanderer Page 6

6-9 Fridge faults and how to cure....................................................

To Wanderer Page 6

 

7-1. Electrical Current in the Motorhome.......................................

To Wanderer Page 7

7-2. The Inverter Converting 12V to 230VAC...............................

To Wanderer Page 7

8-1. Engine Drawings Wiring found inside engine compartment.

To Wanderer Page 8

8-2. SPLIT CHARGE Engine Relay control of the 12 volt electrics to the caravan section................

To Wanderer Page 8

8-3. Zig Control Panel drawing and new voltmeter.....................

To Wanderer Page 8

8-4. Complete Internal Drawing of Caravan area. .....................

To Wanderer Page 8

8-5. Leisure Battery, keeping it topped up...................................

To Wanderer Page 8

8-6. Water Tank Level Meter-modification to electronics.

To Wanderer Page 8

8-7. Faulty fuse Holder Solution.....................................................

To Wanderer Page 8

9-1. Waste Tank Smells. Emergency Action..................................

To Wanderer Page 9

9-2. Washroom odours.........................................................................

To Wanderer Page 9

9-3. Waste Tank Over flow..............................................................

To Wanderer Page 9

9-4. Basin Mixer Taps - tip & how to repair a dripping tap.......

To Wanderer Page 9

9-5. Kitchen sink draining problem...................................................

To Wanderer Page 9

10-1. Wash basin build fault. .............................................................

To Wanderer Page 10

10-2. Shower Tray Repair pattern item produced......................

To Wanderer Page 10

10-3. Wash Basin Photos of Work in progress.............................

To Wanderer Page 10

10-4. Securing fixtures to Caravan Walls......................................

To Wanderer Page 10

10-5. View of wall plugs in use...........................................................

To Wanderer Page 10

10-6. Shower tray repair....................................................................

To Wanderer Page 10

11-1.  Gas Lines in the Wanderer......................................................

To Wanderer Page 11

11-2. Coupling Gas Cylinders...............................................................

To Wanderer Page 11

11-3. Gas Cylinder Safety...................................................................

To Wanderer Page 11

11-4. 'GASLOW' Regulators.............................................................

To Wanderer Page 11

11-5. General Safety...........................................................................

To Wanderer Page 11

12-1. The RCD Description - in the Motorhome, & the Plug Tester

To Wanderer Page 12

12-2. The Mains 230V AC electrical trip device..............................

To Wanderer Page 12

12-3.  Reverse Voltages Continental Sites. Modification............

To Wanderer Page 12

12-4.  The Plug Drawing. Reverse Voltages, Continental Sites modification..............................................................................................

To Wanderer Page 12

13-1.  Fridge Modification - Fitting LED Lamps  to Front Panel of ELECTROLUX RM4200-S Fridge. Also notes on a similar modification to the Fridge 6290....................

To Wanderer Page 13

13-2.  555 Timer used as a Fridge Gas Flame ON Indicator ...

To Wanderer Page 13

14-1.  Modification to  C4 Thetford Toilet, with a 12 Volt immersion pump ...

To Wanderer Page 14

14-2. Thetford Toilet Flushing problems  .....................................

To Wanderer Page 14

15-1. Black Algae in the Thetford Toilet Fresh  Tank................

To Wanderer Page 15

15-2. Build up of Black Algae- Repair Solution.............................

To Wanderer Page 15

15-3. Thetford Toilet Cassette Level indicator  repair.............

To Wanderer Page 15

15-4. Washroom Vehicle Odours. .....................................................

To Wanderer Page 15

15-5. Thetford Toilet Faulty - After layoff................................

To Wanderer Page 15

15-6.Thetford Toilet Seal Fault - and Repair..............................

To Wanderer Page 15

16-1. Calculating a Load on the Back of the Motorhome.........

To Wanderer Page 16

16-2. Calculating vehicle weight from the weighbridge certificate.

To Wanderer Page 16

16-3. The Load Compensating Valve in the Boxer........................

To Wanderer Page 16

17-1. Fitting a New Digital Volt Meter on Control Panel. Plus information on 12 Volt electrics in the Motorhome......

To Wanderer Page 17

18-1.  Getting Ready for Touring & Preparing for the Spring/Summer season..

To Wanderer Page 18

18-2. Checking Pump and Water Heater after a Winter in storage.

To Wanderer Page 18

18-3.Layout Drawing of water system in the Wanderer........

To Wanderer Page 18

18-4.Fresh Water system in Wanderer.........................................

To Wanderer Page 18

18-5. Fresh Water Tank Problem....................................................

To Wanderer Page 18

18-6.Disinfection and Purification of water............................

To Wanderer Page 18

18-7.Water Pump Fault. .....................................................................

To Wanderer Page 18

18-8.Winter preparation....................................................................

To Wanderer Page 18

18-9.The Carver Mk II Vacuum Release Valve fault & repair- See also page 28.

To Wanderer Page 18

18-10.  Carver Water heater also page 28....................................

To Wanderer Page 18

18-12 .Truma Heater 3000 Gas Consumption................................

To Wanderer Page 18

18-13.Carver Water Heater Fault. also page 28..........................

To Wanderer Page 18

19-1.12 Volt operated Water filler for the fresh Water Tank.

To Wanderer Page 19

20-1.Rear Bench Modification. Making it hinged for easy access.

To Wanderer Page 20

21-1. Bike rack installation. also link to another site, which has completed the same installation...........................................................

To Wanderer Page 21

22-1. Buying a Motorhome - Some Tips..............................................

To Wanderer Page 22

23-1. The 'SHUR-flo' Fresh Water Pump, & how it's wired in the Wanderer..

To Wanderer Page 23

23-2. Fitting New Automatic Water System Pump.........................

To Wanderer Page 23

23-3. Winterising the water pump...............................................

To Wanderer Page 23

23-4. Winter Layoff for the Carver boiler.......................................

To Wanderer Page 23

24-1.  Fitting a Fly Screen to Caravan door.....................................
http://www.woolies-trim.co.uk Trim, plus Upholstery & Fittings.

To Wanderer Page 24

25-1.  Fitting of  Drive Away Awning brackets   .............................

To Wanderer Page 25

25-2. Roll out Omnistor awning - unable to wind up and secure inside container..

To Wanderer Page 25

26-1. Holiday Route from Caen, France to Alicante, Spain...........

To Wanderer Page 26

27-1. Ants Problem and how we overcome it....................................

To Wanderer Page 27

27-2. Mosquitos and how we tackled the problem...........................

To Wanderer Page 27

28-1. Frost Precautions-Carver Water Heater. ...............................

To Wanderer Page 28

28-2. Method of Use. Recommended for Carver Water Heater.

To Wanderer Page 28

28-3. Carver Water Heater Safety Warning.  ..................................

To Wanderer Page 28

28-4. Controlling the Carver Water Heater Temperature and Adjustments.....

To Wanderer Page 28

28-5. Carver Water Heater - Safety - Checking testing thge flame...

To Wanderer Page 28

28-6. Carver Water Heater Electrical Supply Notes.......................

To Wanderer Page 28

28-7. Faulty Carver Water Heater, repair hints................................

To Wanderer Page 28

28-8. Cascade Carver Water  Heater Switch  Repair.......................

To Wanderer Page 28

29-1. The Carver 3600 STC Auto Convector Room Heater............

To Wanderer Page 29

30-1. Damaged Light Air Vent in Roof...................................................

To Wanderer Page 30

31-1 Charging Relays in the engine bay - Fault...................................

To Wanderer Page 31

32-1 Wheel Arch Trim Repair..................................................................

To Wanderer Page 32

33-1. Renovating Internal waste Pipe from kitchen sink................

To Wanderer Page 33

34-1. Outside trim Beading Renovation ...............................................

To Wanderer Page 34

34-2. Washroom Air Vent in Ceiling replacement  ...........................

To Wanderer Page 34

35-1  Wanderer Luton Water Ingress & at Feb2011.......................

To Wanderer Page 35

36-1. Stolen Motorhomes.......................................................................

To Wanderer Page 36

37-1  Modifications to the reading lamps using LED Lamps..........

To Wanderer Page 37

37-2. Modified circuit to run LED lamps........................

To Wanderer Page 37

37.3  MR16 X48 Led Lamps 6 X 48 LED lamps...................................

To Wanderer Page 37

38-1 Delamination in the floor of the Motorhome ..........................

To Wanderer Page 38

Home Page:- Back to the entry Home Page and Section heading buttons. Peugeot pages and Satellite pages.